Member Since: 23 Nov 2017
Location: Stevenage
Posts: 990
Transmission adaptions
Hi just wondered how many miles does it take to relearn the adaptions as I have a recon box valve body and torque and although it’s getring better I am still getting harsh gear changes in low gears at lot of the time at low speeds I have only done 140 miles since new box was put in in high gears
They seem a lot betterDisco 3 gone but not forGotten
Welcome disco 4
Flappy paddles working from gap
Heated steering wheel done
Bluetooth iPod connection done
Xeon lights (facelift) done
Afs retrofit done
Logic 7 retrofit done
Armrest fridge
Facelift rear lights
Retrofit High beam assist done
Genuine 22” Range Rover sport alloys
Retrofit acc (gave up not possible)
retrofit tpms done
Retrofit Range Rover lcd digital dash. Done
Retrofit blind spot assist done
It can take an experienced calibrator up to 2 hours to perform a full set of adaptions on a new transmission. You've got to drive in each gear at set speeds and throttle positions for the clutches not engaged for that gear to adapt.
Normally it can take a few hundred miles.1972 Range Rover Classic 2 door V8
2013 Land Rover Discovery 4 HSE - SCRAPPED
2016 Land Rover Discovery 4 Landmark
2022 Volvo XC40 T5 PHEV 282HP FWD 3 cylinder!
5th Mar 2018 1:49 pm
James1974
Member Since: 23 Nov 2017
Location: Stevenage
Posts: 990
So it’s quite normal then ? just after 2500 bill I was getting worried although has to go back in a week for a check anywayDisco 3 gone but not forGotten
Welcome disco 4
Flappy paddles working from gap
Heated steering wheel done
Bluetooth iPod connection done
Xeon lights (facelift) done
Afs retrofit done
Logic 7 retrofit done
Armrest fridge
Facelift rear lights
Retrofit High beam assist done
Genuine 22” Range Rover sport alloys
Retrofit acc (gave up not possible)
retrofit tpms done
Retrofit Range Rover lcd digital dash. Done
Retrofit blind spot assist done
5th Mar 2018 1:51 pm
Bodsy Site Sponsor
Member Since: 06 Nov 2006
Location: In the Clubhouse
Posts: 21361
if the box has been reconditioned, i wouldnt exoect to have harsh gear changes with a worn bnox, yes, but not a good quality reconditioned one, which should have had all the clutch plates checked and where worn, replacedBodsys Brake Bible
Clock/ SNOTM /3Flash / 4x4Info /BT Update /Service Reset/Error Codes / Gearbox Reset See It Here
5th Mar 2018 2:04 pm
James1974
Member Since: 23 Nov 2017
Location: Stevenage
Posts: 990
I had a fully reconditioned box installed not my own reconditioned I also had a new torque convertor installed and valve body done as well it’s not too harsh but can defently notice it if I slow down to quickly and then pull away again quickly it’s as if it’s holding the gear as a slow down if that makes any sense
Wonder if it’s worth while me resetting the adaptions with my iid tool but they must of done it as he did sit down and explain the box need a while to re learn the new adaptions
Another thing as well is my iid tool says there is a software update for my boxDisco 3 gone but not forGotten
Welcome disco 4
Flappy paddles working from gap
Heated steering wheel done
Bluetooth iPod connection done
Xeon lights (facelift) done
Afs retrofit done
Logic 7 retrofit done
Armrest fridge
Facelift rear lights
Retrofit High beam assist done
Genuine 22” Range Rover sport alloys
Retrofit acc (gave up not possible)
retrofit tpms done
Retrofit Range Rover lcd digital dash. Done
Retrofit blind spot assist done
5th Mar 2018 2:17 pm
Gareth Site Moderator
Member Since: 07 Dec 2004
Location: Bramhall
Posts: 26767
I would not do any messing with it. You’ve spent a lot of money, you should let them deal with it.
5th Mar 2018 4:27 pm
James1974
Member Since: 23 Nov 2017
Location: Stevenage
Posts: 990
I think u right mate
Another thing I noticed that if I go from drive to reverse it clunks a bit and from reverse to drive it clunks a bit so if I go back and forth it clunks every time
I drove a mates one earlier and his has done 140000 and not one clunk at allDisco 3 gone but not forGotten
Welcome disco 4
Flappy paddles working from gap
Heated steering wheel done
Bluetooth iPod connection done
Xeon lights (facelift) done
Afs retrofit done
Logic 7 retrofit done
Armrest fridge
Facelift rear lights
Retrofit High beam assist done
Genuine 22” Range Rover sport alloys
Retrofit acc (gave up not possible)
retrofit tpms done
Retrofit Range Rover lcd digital dash. Done
Retrofit blind spot assist done
5th Mar 2018 4:34 pm
Bodsy Site Sponsor
Member Since: 06 Nov 2006
Location: In the Clubhouse
Posts: 21361
Clock/ SNOTM /3Flash / 4x4Info /BT Update /Service Reset/Error Codes / Gearbox Reset See It Here
5th Mar 2018 7:17 pm
James1974
Member Since: 23 Nov 2017
Location: Stevenage
Posts: 990
Ive rung them and they said it does sound like something they need to look at as don’t sound right so dropping it back to them on WednesdayDisco 3 gone but not forGotten
Welcome disco 4
Flappy paddles working from gap
Heated steering wheel done
Bluetooth iPod connection done
Xeon lights (facelift) done
Afs retrofit done
Logic 7 retrofit done
Armrest fridge
Facelift rear lights
Retrofit High beam assist done
Genuine 22” Range Rover sport alloys
Retrofit acc (gave up not possible)
retrofit tpms done
Retrofit Range Rover lcd digital dash. Done
Retrofit blind spot assist done
5th Mar 2018 7:30 pm
James1974
Member Since: 23 Nov 2017
Location: Stevenage
Posts: 990
At £2500 they can have it back now till it’s fixed properly they are a zf approved garage as wellDisco 3 gone but not forGotten
Welcome disco 4
Flappy paddles working from gap
Heated steering wheel done
Bluetooth iPod connection done
Xeon lights (facelift) done
Afs retrofit done
Logic 7 retrofit done
Armrest fridge
Facelift rear lights
Retrofit High beam assist done
Genuine 22” Range Rover sport alloys
Retrofit acc (gave up not possible)
retrofit tpms done
Retrofit Range Rover lcd digital dash. Done
Retrofit blind spot assist done
5th Mar 2018 7:33 pm
M3DPO
Member Since: 22 Sep 2010
Location: Notts.
Posts: 8219
If it is a ZF reconditioned GB and TC you should not have a problem and it should have at least 12 months warranty. Most ZF authorised agents only fit ZF reconditioned units, they don't work on them themselves, if you have not got the correct software that may be your problem, it is available from GAP for a small charge with their fast track system, but you should be going back and telling them it is not the latest software.
In the meantime run it as gently and as smooth as you can until the adaptions adapt to your style of driving.It can when others can't,
It will when others won't,
It goes where others don't.
5th Mar 2018 10:07 pm
James1974
Member Since: 23 Nov 2017
Location: Stevenage
Posts: 990
Yes mate it is a recon from zf and torque from zf and yes year warranty or 14000 miles
It has got a lot better since picking it up and seems to be getting better all the time and he did explain at the time that it does take time To learn the new adaptions it does seem smooth through the higher gears but
the low gears seem to clonk not all the time though
Do u think I should leave it another week and see if it does get better only got it back last Tuesday and only done 150 odd miles since it was doneDisco 3 gone but not forGotten
Welcome disco 4
Flappy paddles working from gap
Heated steering wheel done
Bluetooth iPod connection done
Xeon lights (facelift) done
Afs retrofit done
Logic 7 retrofit done
Armrest fridge
Facelift rear lights
Retrofit High beam assist done
Genuine 22” Range Rover sport alloys
Retrofit acc (gave up not possible)
retrofit tpms done
Retrofit Range Rover lcd digital dash. Done
Retrofit blind spot assist done
5th Mar 2018 10:24 pm
James1974
Member Since: 23 Nov 2017
Location: Stevenage
Posts: 990
This is my software from the iid tool does it look like
It needs a flash does say there is a undate available
Disco 3 gone but not forGotten
Welcome disco 4
Flappy paddles working from gap
Heated steering wheel done
Bluetooth iPod connection done
Xeon lights (facelift) done
Afs retrofit done
Logic 7 retrofit done
Armrest fridge
Facelift rear lights
Retrofit High beam assist done
Genuine 22” Range Rover sport alloys
Retrofit acc (gave up not possible)
retrofit tpms done
Retrofit Range Rover lcd digital dash. Done
Retrofit blind spot assist done
5th Mar 2018 10:27 pm
gstuart
Member Since: 21 Oct 2016
Location: kent
Posts: 14103
M3DPO wrote:
If it is a ZF reconditioned GB and TC you should not have a problem and it should have at least 12 months warranty. Most ZF authorised agents only fit ZF reconditioned units, they don't work on them themselves, if you have not got the correct software that may be your problem, it is available from GAP for a small charge with their fast track system, but you should be going back and telling them it is not the latest software.
In the meantime run it as gently and as smooth as you can until the adaptions adapt to your style of driving.
hi
may i ask , is that to do with the california stop update plse
ie, if after an ATF lfluid change u reset the adaptions and then update via the iid with the fast track software , thks
Last edited by gstuart on 6th Mar 2018 4:20 am. Edited 4 times in total
6th Mar 2018 3:44 am
gstuart
Member Since: 21 Oct 2016
Location: kent
Posts: 14103
James1974 wrote:
This is my software from the iid tool does it look like
It needs a flash does say there is a undate available
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum
