Nkelly007
Member Since: 17 Apr 2011
Location: South Africa
Posts: 1
![](templates/vbnew/images/spacer.gif)
![2008 LR3 TDV6 SE Auto Zambezi Silver 2008 LR3 TDV6 SE Auto Zambezi Silver](../images/veh/zambezi_silver.gif)
|
LR3 Air Suspension Compressor |
|
I had the intermittent suspension warning light issue for a while, sometimes it doesn't come on for days, some days it comes on and stays on all the time.
I eventually went into Land Rover for it to be checked out. The computer check mentioned issues with the rate at which the suspension was lifting. The dealer decided to replace the compressor at a cost of £800 (car is still on its motorplan, so no costnto me).
some interesting discussion points I had with the dealer during the exercise:
1. the new part has a different part number, this is because all pre-2008 lr3 had a factory fitted part known for an issue resolved in the new part
2. A very common reason for the compressor failing is due to car jacking. The pump is located just in front of the rear left wheel and is often mistaken for a jacking point. 2,5 tons of vehicle hanging on the compressor turns out to be a bad thing.
3. Apparently this problem can put the car in limp mode, and would be hesitant about DIY fixes if this happens to you.
|
17th Apr 2011 6:06 pm |
|
|
Benny
Member Since: 24 Aug 2010
Location: Devon
Posts: 23
![](templates/vbnew/images/spacer.gif)
![2015 Discovery 4 3.0 SDV6 HSE Auto Firenze Red 2015 Discovery 4 3.0 SDV6 HSE Auto Firenze Red](../images/veh/firenze_red.gif)
|
Since having the compressor changed all been o.k. Still got the old one in the garage - too damn cold last leave - and too lazy to check it out and see if there was any obvious faults - will have to next leave. Fitting the new compressor would have cleaned up the connections so will be interesting to see if anything actually wrong with it. Benny
SDV6 Disco4 HSE
Defender TD5 90 Hard top
Aston Marton DB9.2
|
19th Apr 2011 11:50 pm |
|
|
curlycol
Member Since: 12 Apr 2011
Location: Scotland
Posts: 5
![](templates/vbnew/images/spacer.gif)
![2005 Discovery 3 TDV6 S Manual Santorini Black 2005 Discovery 3 TDV6 S Manual Santorini Black](../images/veh/santorini_black.gif)
|
slight tangent on the previous posts but.....
I have reoccurring issues with wiring harness on my D3 failing, apparently a design flaw with the D3 where water can't get away from where the harness lies in the chassis meaning that a 5yr old 40k rough tough 4x4 needs a new wiring harness or a lifetime's supply of spade connectors and single core wire!
Anyone recommend the best place to source a wiring loom? half a plan to replace myself as losing trust in the local stealers pretty fast,
pretty gutted that the warranty does not cover wiring.... Dark Disco 3 - 20" but chunky tyres
|
6th Jun 2011 2:06 pm |
|
|
minty2010
Member Since: 09 Feb 2012
Location: Haworth West Yorkshire
Posts: 31
![](templates/vbnew/images/spacer.gif)
![2008 Discovery 3 TDV6 HSE Auto Maya Gold 2008 Discovery 3 TDV6 HSE Auto Maya Gold](../images/veh/maya_gold.gif)
|
have had intermittent suspension height problems, only shows when at speed on motorways, been into landrover twice to fix both times they have said they have changed the height sensors, and 1 EGR valve, it is a 08 HSE with 65000 on the clock,
|
27th May 2012 5:28 am |
|
|
philburt
Member Since: 31 Jul 2011
Location: North west
Posts: 17
![](templates/vbnew/images/spacer.gif)
|
Suspension fault normal height only - another one! |
|
Hi,
I have now had my 06 plate auto tdv6 for just over a year - its now on about 130k mileage.
Since getting it I have had two fault messages "transmission fault - reduced traction" which has come up two or three times in 12 months. And "suspension fault - normal height only which also came up a couple of times over the twelve months untill a few weeks ago when it became regular.
Here are the symptoms:
After starting up suspension raises and lowers no problem.
When driving in normal height after about 4 minutes the fault message comes up and disables the air suspension.
This happened every day for a week, then it was okay for about a week and now its doing it again.
If I raise and lower the suspension once the front rises ever so slightly slower than the back.
If I raise and lower it about three times the front slows down dramaticaly and I get the message "suspension raising slowly" - this may be normal after its been up and down a few times though?
I dont have a fault code reader and I know that using one will be required at some point but I am just looking for your advice about the most likely cause - so I can prepare myself for the financial shock!
Finaly - do any of the fault code readers have the facility to calibrate air suspension.
Your advice - suggestions would be appreciated.
Phil
|
10th Oct 2012 10:50 am |
|
|
D4JWW
Member Since: 20 Oct 2009
Location: London, UK
Posts: 1318
![](templates/vbnew/images/spacer.gif)
![2009 Discovery 3 TDV6 GS Manual Stornoway Grey 2009 Discovery 3 TDV6 GS Manual Stornoway Grey](../images/veh/stornoway_grey.gif)
|
Phil
Its always good to start with basics:
1) battery condition, fully charged with batt charge.
2)done hard reset
I can't see model year, if it's pre07 without compressor software and relay update it's likely to be the compressor dying.
Faultmate and IIdtool can read Fcodes and calibrate susp. Best to get codes read or beter get a site sponsor to look at your D3. A few mods... and keeping it all running...Faultmate MSV2
MY09EGR's blanked Thanks Bellautos, BAS
|
10th Oct 2012 12:33 pm |
|
|
philburt
Member Since: 31 Jul 2011
Location: North west
Posts: 17
![](templates/vbnew/images/spacer.gif)
|
Thanks D4JWW,
I think the battery is fine but I will check it and do the hard reset this weekend.
|
10th Oct 2012 1:16 pm |
|
|
powernut
Member Since: 17 Sep 2013
Location: doncaster
Posts: 53
![](templates/vbnew/images/spacer.gif)
|
I just a 55 plate d3 tdv6 auto 2.7 tdv6 , noticed yellow suspention fault , wont lift the front , rear will raise , after plugging in my fault reader (didn't know its got everything for the d3/4 along with a good depth system of the vechical , I could hear air once I cleared the fault , turned out to be a split in a green pipe hiddern in the plastic under plate of the ns of the car ,,,all working great at the moment ,,
|
10th Oct 2013 11:41 pm |
|
|
Beeredup
Member Since: 03 Mar 2014
Location: Fleetwood
Posts: 160
![](templates/vbnew/images/spacer.gif)
![2007 Discovery 3 TDV6 SE Auto Zambezi Silver 2007 Discovery 3 TDV6 SE Auto Zambezi Silver](../images/veh/zambezi_silver.gif)
|
My D3 has suddenly come up with the normal height only message and suspension fault when i went to start it? is it safe to drive? or should i be getting it to a garage quick?
|
14th Apr 2014 2:16 pm |
|
|
|
Beeredup
Member Since: 03 Mar 2014
Location: Fleetwood
Posts: 160
![](templates/vbnew/images/spacer.gif)
![2007 Discovery 3 TDV6 SE Auto Zambezi Silver 2007 Discovery 3 TDV6 SE Auto Zambezi Silver](../images/veh/zambezi_silver.gif)
|
yeah its still at normal height i noticed the other morning it had crept down over night and the other day it went into extended mode on me when i put in offroad mode to clean the sills? looks like i am gonna have to book it in the garage and see if they can get it fixed before weekend
|
14th Apr 2014 2:26 pm |
|
|
Beeredup
Member Since: 03 Mar 2014
Location: Fleetwood
Posts: 160
![](templates/vbnew/images/spacer.gif)
![2007 Discovery 3 TDV6 SE Auto Zambezi Silver 2007 Discovery 3 TDV6 SE Auto Zambezi Silver](../images/veh/zambezi_silver.gif)
|
whats the process? do they plug in read the fault first and then replace whats bust?
any idea on average costs? (just so i dont get my trolleys yanked)
|
14th Apr 2014 2:31 pm |
|
|
Disco_Mikey
Member Since: 29 May 2007
Location: Dundee, Scotland
Posts: 20790
![](templates/vbnew/images/spacer.gif)
![2005 Discovery 3 TDV6 HSE Auto Cairns Blue 2005 Discovery 3 TDV6 HSE Auto Cairns Blue](../images/veh/cairns_blue.gif)
|
Plug in and read the fault codes.
From what you are saying, it sounds very much like an air leak. Usually the dryer or air reservoir is at fault
New dryer is £70 + fitting at around an hour, IIRC
Reservoir is similar My D3 Build Thread
TDV8 Retrofit Build Thread
|
14th Apr 2014 2:36 pm |
|
|
Beeredup
Member Since: 03 Mar 2014
Location: Fleetwood
Posts: 160
![](templates/vbnew/images/spacer.gif)
![2007 Discovery 3 TDV6 SE Auto Zambezi Silver 2007 Discovery 3 TDV6 SE Auto Zambezi Silver](../images/veh/zambezi_silver.gif)
|
Cheers gotta ring our local independent back in an hour or so as he is out on a recovery, he said from what i said its an air leak as you can hear the compressor running
|
14th Apr 2014 2:46 pm |
|
|
m545i
Member Since: 05 Mar 2014
Location: Aarschot
Posts: 4
![](templates/vbnew/images/spacer.gif)
![2005 Discovery 3 TDV6 HSE Lux Auto Santorini Black 2005 Discovery 3 TDV6 HSE Lux Auto Santorini Black](../images/veh/santorini_black.gif)
|
Drying the dessicant helped me for already 4 months now. Diagnosis said slow pressure build up, Compressor to be replaced following LR...
Now overnight it sinks somewhat, will check with water and soap for the leak.
|
3rd Jul 2014 7:34 pm |
|
|