Member Since: 30 Nov 2022
Location: London
Posts: 18
Coolant disappearing - EGR cooler leak?
Hello there. Anyone can give me a little advice please? I hear that coolant can leak thru EGR cooler. But I am not sure if this would be also visible on the outside. I snapped quickly a photo of where EGR is connected to its cooler.
My main issue is that I started noticing loss of coolant since around Winter. And lately I noticed that the engine oil level increased slightly. In fact sometime it shows normal level, sometime increased so that suggests the water might be getting in. Obviously my worst scenario is the head gasket but since I have started noticing the issues, I haven’t had any other symptoms of head gasket issue i.e. milky oil, white gases from exhaust..
Any advice, direction is much appreciated.
26th May 2023 7:56 am
Breg90
Member Since: 04 Feb 2017
Location: Falkirk
Posts: 360
It might be the oil cooler that is water cooled - it’s under the oil filter in the v of the engineSeries one 1949 - in bits, chassis is strapped to the ceiling in my garage (beside the canoe)
LR 90 - In bits
Disco 3 - currently in bits
27th May 2023 8:40 am
ronp
Member Since: 29 Nov 2006
Location: North Yorkshire
Posts: 15266
Yes, I’d say that it’s most likely the egr cooler.
Member Since: 30 Nov 2022
Location: London
Posts: 18
Thanks Ronp.
I’ll read your issue. Btw I did test the cooling system for presence of exhaust gasses. And that came negative so I am hoping and excluding the head gasket for now.
Last edited by mirosD3 on 29th May 2023 5:07 am. Edited 1 time in total
28th May 2023 6:30 pm
mirosD3
Member Since: 30 Nov 2022
Location: London
Posts: 18
Ronp
And you basically tested it with blanking off EGRs??
ronp wrote:
Yes, I’d say that it’s most likely the egr cooler.
Member Since: 29 Nov 2006
Location: North Yorkshire
Posts: 15266
PM replied to. ...... always on the road less travelled 🚧
‘tis but a mere scratch …….. it’ll polish out.
29th May 2023 8:26 am
Prette
Member Since: 16 Mar 2020
Location: Previously Stoke-ST4 (pre-pandemic), Mostly The Hague (NL) partially Lyngby (DK) certainly somewhere
Posts: 160
Re: Coolant disappearing - EGR cooler leak?
ronp wrote:
PM replied to.
Hi folks. Is the discussion via PM perhaps relevant to help others in here to solve the same issue?
Anyways…
mirosD3 wrote:
My main issue is that I started noticing loss of coolant since around Winter.
Any advice, direction is much appreciated.
Is your coolant leak constant (i.e. emptying the coolant tank?) or does it “stop” right below the “Min.” level?
Have you thought about the coolant “manifold” (or whatever is called the plastic part on top of the engine - right in the V)? Couple of years ago a had a similar mysterious coolant leak I could not see where it came from. Easy and cheap job to tackle.
Just an idea for you to check/rule-out.
30th May 2023 1:21 pm
mirosD3
Member Since: 30 Nov 2022
Location: London
Posts: 18
I did actually changed the thermostat not long ago as I thought that was initially the issue. It turned out all dry while changing it.
I still don’t understand how the water would leak into the EGR valve as the EGR cooler and the water inside is seperated.
30th May 2023 2:39 pm
mirosD3
Member Since: 30 Nov 2022
Location: London
Posts: 18
Quick update. The issue was the EGR cooler. It got burst from within inside and the water was getting sucked into the air intake and the engine eventually.
Just before I was getting it checked by my mechanic, got stuck on the motorway with completely emptied water through the expansion bottle.
Later realised this was caused by leaky EGR cooler.
The Saga continues Now after the EGR cooler was replaced. The coolant seems to be still disappearing. Now I suspect the head gasket…
4th Aug 2023 9:58 pm
M3DPO
Member Since: 22 Sep 2010
Location: Notts.
Posts: 8242
If it’s the head gasket the engine would be overheating!
Fill the radiator and expansion bottle full of coolant leave the expansion cap off, start the engine and let it run at tick over, look for bubbles coming out of the coolant bottle, if you can see bubbles coming out of the coolant a cylinder head gasket is faulty, if not the head gaskets are ok.It can when others can't,
It will when others won't,
It goes where others don't.
5th Aug 2023 9:24 am
asj968
Member Since: 01 Jul 2008
Location: Kent
Posts: 75
Hi - reading with interest - particularly the comment "Is your coolant leak constant (i.e. emptying the coolant tank?) or does it “stop” right below the “Min.” level?
Have you thought about the coolant “manifold” (or whatever is called the plastic part on top of the engine - right in the V)? Couple of years ago a had a similar mysterious coolant leak I could not see where it came from. Easy and cheap job to tackle."
Does anyone have any information on this as struggling to search without the correct terms. My water leak is stopping just below the min level and there is coolant on top of the engine just below the oil filter area - the coolant is then running off and dripping down the engine and off the rear of the underside protection plate.Porsche 968 Cabrio
Discovery 4 HSE 3.0
30th Sep 2024 11:24 am
Pete K
Member Since: 15 Jan 2016
Location: GL
Posts: 10730
If you search for "tdv6 thermostat" on ebay you will get loads of results and part numbers.
It's not a thermostat though! More a bridge between heads
Thermostat is white
30th Sep 2024 11:30 am
Breg90
Member Since: 04 Feb 2017
Location: Falkirk
Posts: 360
Consider if the little fuel cooler on the top of the oil filter housing is leaking - mine was leaking at the O rings between the little cooler and the body of the oil filter housing. You could see cprrosionm from the coolant on the aluminium.Series one 1949 - in bits, chassis is strapped to the ceiling in my garage (beside the canoe)
LR 90 - In bits
Disco 3 - currently in bits
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum
Now after the EGR cooler was replaced. The coolant seems to be still disappearing. Now I suspect the head gasket…
