Member Since: 01 Dec 2011
Location: cornwall
Posts: 10146
Special programs off and engine fault !!!!!!!!!!!!!!!!
Well after 6 months of this happening we still can't find the problem , it happens 3-4 times a week , put it in neutral for 3-4 seconds with feet of everything as your still coasting and then fine again
Injector readings seem ok when they were read , actuator seems ok , could it be a hose ? , it's only when asking for power up a hill . Any other thing I can check before I go totally mad with it !!!!!!!!!!-------------------------------------------------
if you cant hold on dont let go , it ill come in handy for something even if you never use it.
D3 SE 05,
110 s wagon 300 tdi SOLD
h top transit
crew cab transit
transit connect
ausa dumper, muck truck .
peljob 2.5 digger
06 L 200 crew cab
31st Oct 2015 9:14 am
Disco_Mikey
Member Since: 29 May 2007
Location: Dundee, Scotland
Posts: 20786
Member Since: 01 Dec 2011
Location: cornwall
Posts: 10146
Codes were read a couple months ago by woody , I'll ask if he can call in next week again , ( I must get my new BT tool set up ) but if I remember nothing much came up , I am now getting off with it and loosing all confidence with it , if I'm in low range towing the digger , that's 3.5 tonne on the back it don't happen ???
Time to go back to a 110 sooooooon-------------------------------------------------
if you cant hold on dont let go , it ill come in handy for something even if you never use it.
D3 SE 05,
110 s wagon 300 tdi SOLD
h top transit
crew cab transit
transit connect
ausa dumper, muck truck .
peljob 2.5 digger
06 L 200 crew cab
31st Oct 2015 9:21 am
Bodsy Site Sponsor
Member Since: 06 Nov 2006
Location: In the Clubhouse
Posts: 21361
These are the codes from August Stew.
Vehicle scanned on 28-08-2015 13:54
Using IIDTool Pro V3.0 B2520
Airbag
B1A00-17 (2C) Unknown
( at 142146 mi )
B00DF-00 (AC) Passenger restraints disable switch
( at 141255 mi )
Audio System
U1A03-62 (28) Vehicle configuration parameter - Algorithm based failure - signal compare failure
( at 150110 mi )
U2003-25 (28) Fibre optic communication bus - General signal failure - signal shape/waveform failure
( at 150110 mi )
U2003-81 (28) Fibre optic communication bus - Bus signal/message failure - invalid serial data received
( at 150102 mi )
Body Control
B1B01-87 (6C) Key transponder - Bus signal/message failure - missing a message
( at 146016 mi )
B1B55-1C (2F) Rain sensor module - General electrical failure - circuit voltage out of range
( at 141287 mi )
B1B69-16 (2E) 12 volt supply circuit - General electrical failure - circuit voltage below threshold
( at 141200 mi )
B1B70-81 (28) Local interconnection network bus circuit 2 - Bus signal/message failure - invalid serial data received
( at 141219 mi )
B1B91-3A (2F) Seat tilt motor speed/position sensor - Frequency modulation/pulse width modulation failure - incorrect, has too many pulses
B1C09-73 (2F) Driver's left/right mirror motor circuit - Mechanical failure - actuator is stuck closed
( at 141200 mi )
B1C10-73 (2F) Driver's up/down mirror motor circuit - Mechanical failure - actuator is stuck closed
( at 141200 mi )
B1C11-73 (28) Passenger's left/right mirror motor circuit - Mechanical failure - actuator is stuck closed
( at 141200 mi )
B1C12-73 (28) Passenger's up/down mirror motor circuit - Mechanical failure - actuator is stuck closed
( at 141200 mi )
B1C13-3A (2E) Driver's up/down mirror motor feedback circuit - Frequency modulation/pulse width modulation failure - incorrect, has too many pulses
( at 141200 mi )
B1C14-3A (2E) Driver's left/right mirror motor feedback circuit - Frequency modulation/pulse width modulation failure - incorrect, has too many pulses
( at 141200 mi )
B1C26-3A (2F) Pedal motor feedback circuit - Frequency modulation/pulse width modulation failure - incorrect, has too many pulses
( at 141200 mi )
B1C32-13 (2F) Steering column tilt solenoid - General electrical failure - circuit open
( at 141200 mi )
B1C33-3A (28) Steering column tilt feedback signal - Frequency modulation/pulse width modulation failure - incorrect, has too many pulses
( at 142604 mi )
B1C34-13 (2F) Steering column telescope solenoid - General electrical failure - circuit open
( at 141200 mi )
B1C35-3A (28) Steering column telescope feedback signal - Frequency modulation/pulse width modulation failure - incorrect, has too many pulses
( at 142604 mi )
B1C60-12 (68) Sidelamps relay output circuit - General electrical failure - circuit short to battery
( at 144027 mi )
B1D07-15 (28) Right turn signal circuit - General electrical failure - circuit short to battery or open
( at 143406 mi )
B1D08-15 (28) Left trailer turn signal circuit - General electrical failure - circuit short to battery or open
( at 144394 mi )
B1D09-15 (28) Right trailer turn signal circuit - General electrical failure - circuit short to battery or open
( at 141523 mi )
U0155-87 (28) Lost communication with instrument cluster control module - Bus signal/message failure - missing a message
( at 144394 mi )
Engine TDV6
P2290-00 (68) Unknown
Parking Brake
C1A00-17 (A8) Control module - General electrical failure - circuit voltage above threshold
( at 141221 mi )
Transfer Case
P0563-00 (28) System voltage high
( at 141287 mi )
P0780-00 (28) Shift malfunction
( at 143300 mi )
Vehicle Dynamic
U0424-68 (08) Unknown
( at 141253 mi )
U0132-87 (08) Lost communication with ride level control module - Bus signal/message failure - missing a message
( at 149244 mi )
Ventilation
B1B74-00 (68) Front foot-defrost mode stepper actuator
( at 141221 mi )
B1B75-00 (68) Front foot-face mode stepper actuator
( at 141287 mi )
B1B76-00 (68) Front left air blend stepper actuator
( at 141287 mi )
B1B77-00 (68) Front right air blend stepper actuator
( at 141287 mi )
Then cleared them and re read to these (but didn't drive anywhere)
Vehicle scanned on 28-08-2015 13:56
Using IIDTool Pro V3.0 B2520
Body Control
B1B91-3A (2F) Seat tilt motor speed/position sensor - Frequency modulation/pulse width modulation failure - incorrect, has too many pulses
( at 150110 mi )
B1C09-73 (2F) Driver's left/right mirror motor circuit - Mechanical failure - actuator is stuck closed
( at 150110 mi )
B1C10-73 (2F) Driver's up/down mirror motor circuit - Mechanical failure - actuator is stuck closed
( at 150110 mi )
B1C26-3A (2F) Pedal motor feedback circuit - Frequency modulation/pulse width modulation failure - incorrect, has too many pulses
( at 150110 mi )
B1C32-13 (2F) Steering column tilt solenoid - General electrical failure - circuit open
( at 150110 mi )
B1C34-13 (2F) Steering column telescope solenoid - General electrical failure - circuit open
( at 150110 mi )
Clock/ SNOTM /3Flash / 4x4Info /BT Update /Service Reset/Error Codes / Gearbox Reset See It Here
31st Oct 2015 9:32 am
stew 46
Member Since: 01 Dec 2011
Location: cornwall
Posts: 10146
Cheers Bodsy forgot about them
I will Gareth -------------------------------------------------
if you cant hold on dont let go , it ill come in handy for something even if you never use it.
D3 SE 05,
110 s wagon 300 tdi SOLD
h top transit
crew cab transit
transit connect
ausa dumper, muck truck .
peljob 2.5 digger
06 L 200 crew cab
31st Oct 2015 9:32 am
Disco_Mikey
Member Since: 29 May 2007
Location: Dundee, Scotland
Posts: 20786
P2290 - low fuel pressure
Blocked filter
In tank pump
HP pump
Fuel leak/drawing airMy D3 Build Thread
Member Since: 01 Dec 2011
Location: cornwall
Posts: 10146
Fitted a new genuine filter 6 weeks ago
I tank pump sounds like the next thing to change , ideas on costs ?-------------------------------------------------
if you cant hold on dont let go , it ill come in handy for something even if you never use it.
D3 SE 05,
110 s wagon 300 tdi SOLD
h top transit
crew cab transit
transit connect
ausa dumper, muck truck .
peljob 2.5 digger
06 L 200 crew cab
31st Oct 2015 9:47 am
DSL Keeper of the wheelie bin
Member Since: 11 May 2006
Location: Off again! :-)
Posts: 72930
Genuine filter? Some others have a problem with high fuel throughput. Had that on mine.
31st Oct 2015 10:03 am
stew 46
Member Since: 01 Dec 2011
Location: cornwall
Posts: 10146
[quote="stew 46"]Fitted a new genuine filter 6 weeks ago -------------------------------------------------
if you cant hold on dont let go , it ill come in handy for something even if you never use it.
D3 SE 05,
110 s wagon 300 tdi SOLD
h top transit
crew cab transit
transit connect
ausa dumper, muck truck .
peljob 2.5 digger
06 L 200 crew cab
31st Oct 2015 10:08 am
DSL Keeper of the wheelie bin
Member Since: 11 May 2006
Location: Off again! :-)
Posts: 72930
PS: Have they gone down in price, only that sounds a touch cheaper than I thought (thought they were £3xx)? Current: Discovery 3 06MY (55 reg) HSE Auto Zambezi Silver Allisport Fast Road Intercooler, V8 Brakes, Silicone IC Hoses, EGRs Blanked, Remapped, De-Cat pipe, FBHIC
Freelander 2 2007 HSE Manual Tambora Flame
Previous: FL2 56 reg SE Manual Black (written off )
Disco 3 06 reg B7S Manual Rimini Red
Disco 2 TD5 Y reg ES Manual Blue - Chipped
Several Discovery 300 TDis
31st Oct 2015 10:24 am
Disco_Mikey
Member Since: 29 May 2007
Location: Dundee, Scotland
Posts: 20786
Aha. Current: Discovery 3 06MY (55 reg) HSE Auto Zambezi Silver Allisport Fast Road Intercooler, V8 Brakes, Silicone IC Hoses, EGRs Blanked, Remapped, De-Cat pipe, FBHIC
Freelander 2 2007 HSE Manual Tambora Flame
Previous: FL2 56 reg SE Manual Black (written off )
Disco 3 06 reg B7S Manual Rimini Red
Disco 2 TD5 Y reg ES Manual Blue - Chipped
Several Discovery 300 TDis
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum
, it happens 3-4 times a week , put it in neutral for 3-4 seconds with feet of everything as your still coasting and then fine again 
forgot about them 
Allisport Fast Road Intercooler, V8 Brakes, Silicone IC Hoses, EGRs Blanked, Remapped, De-Cat pipe, FBHIC
)
