Member Since: 29 Aug 2012
Location: N Yorks
Posts: 1936
Aircon fault
Had new front to rear pipework replaced on aircon system on Thursday. All good, very cold. Today blowing warm again Pipe in engine bay is cold but checked live values - evaporator temp around 26.5 °C! Air con system pressure around 262kpa. When I switch on the aircon I hear the farting sound as usual but this sound is repeated every couple of seconds.
There aren't any related fault codes but when I cleared faults earlier the aircon started to blow cold. Half an hour later went for a drive and had stopped working again!
Any ideas?
27th Jun 2015 3:33 pm
lynalldiscovery
Member Since: 22 Dec 2009
Location: Maidstone
Posts: 7274
Mine held vac test just fine but still lost pressure, replaced pipe same as yours and its been fine since, after it lost pressure after a week or so I pressurised the system with nitrogen (any air con place can do the same) and found the leak with the help of a soapy water bottle.
27th Jun 2015 9:14 pm
RBP
Member Since: 29 Aug 2012
Location: N Yorks
Posts: 1936
Thanks for the reply Spent loads lately so don't want to throw any more at the old beast! Just my luck there's a heatwave coming At least the electric windows are still working!
28th Jun 2015 7:31 am
lynalldiscovery
Member Since: 22 Dec 2009
Location: Maidstone
Posts: 7274
Maybe cheap ways around it, the a/c guy reckoned the system can run at pressures to 6 bar and he tests them to 10 bar for stubborn leaks, I only tried it at 4 bar or so, well within the range of a standard air compressor, and so long as its gets a good vac down before recharge to boil of any moisture that has got into the system.
All you would need is some sort of adaptor to pressurise the system, maybe something on ebay?
Just thinking if it ran for half an hour maybe pressure is just fine and you have a elec/sensor fault, get wiring diagram and have a play.
You can also get the aerosol recharge can from ebay etc, I have used them in the past and they do work no matter what the scare mongers say!
Cheap enough so maybe get can add to system and if it then runs for more than 1/2 hour you know its just low gas.
28th Jun 2015 2:56 pm
RBP
Member Since: 29 Aug 2012
Location: N Yorks
Posts: 1936
Will try & get to the bottom of this tomorrow. Thought the recurring farting noise could be a problem with the air-con recirculation motor? Fed up with my Dad saying " When I was a lad we wound down the windows, and you could get have 8 pints, fish & chips and still have change from a farthing" blah blah.....
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum