Member Since: 01 Oct 2014
Location: Twickenham
Posts: 433
2nd hand unit on way...should be here Thursday, fingers crossed it works as it's from a D3.
Will post when done with any hints /tips to help anybody else.
26th May 2015 8:45 pm
crip010
Member Since: 01 Oct 2014
Location: Twickenham
Posts: 433
Sunroof arrived from really nice chap 2nd hand.
Very simple to swap, 3 torx bolts each side, just popped in glass, put on 2 of the bolts front and back both sides and then lifted roof to put in final one.
You then need to make sure the sunroof is flush to the car, so keep the bolts loose and adjust the back then the front and tighten them all up.
The only word of warning is don't drop a bolt as they are hard to get out of the channel.
Finally I have greased up the rubber now!!
28th May 2015 12:37 pm
Dannyson
Member Since: 14 Oct 2014
Location: Newquay, Cornwall
Posts: 820
What grease have you used please?2016MY Discovery HSE - Black
2009MY Toyota Land Cruiser (Lc4) - Black
28th May 2015 1:25 pm
crip010
Member Since: 01 Oct 2014
Location: Twickenham
Posts: 433
I appreciate this thread is getting on but I've got exactly the same going in with my 2009 Discovery 3 (see image)
Is anyone aware of a solution? You can buy a replacement pane and swap it out (3 bolts each side) BUT that's absolutely ridiculous when its almost £500 and the rubber seal is the only bit that has failed (circa £50 on any other car). One could get a second hand pane but then this will be an old seal which will likely do the same at some point.
Thanks
Paul
17th Apr 2018 2:42 pm
crip010
Member Since: 01 Oct 2014
Location: Twickenham
Posts: 433
no other solution, just buy second hand, my 2nd hand one was from a D3 so older than my car and still fine.
Damn! I hoped there would be a way of putting a brand new seal on it without spending stupid money to do so. Ah well, I either go second hand like you say it it accidentally gets cracked and if auto glass will replace under normal glass cover on insurance.
Thanks for your input though 👍
17th Apr 2018 6:41 pm
Beretta
Member Since: 11 Oct 2012
Location: Rochdale
Posts: 1180
I don’t think sunroofs are covered under a standard glass policy.
Just a quick question-What’s the best thing to use to treat / clean these seals with so they don’t get worse.2010 Disco 4 HSE
- Digital Dash Club
- GAP BT IID
17th Apr 2018 7:19 pm
crip010
Member Since: 01 Oct 2014
Location: Twickenham
Posts: 433
Yeah autoglass will replace all the other 10 panes of glass but not the roof. How odd
RE a second hand one, can anyone confirm that ALL discovery 3 and 4 and all spec revisions all used the same sunroof? I'd rather buy as newer one as I can so the seal will last longer. I've seen a 2015 one and asked the seller but they haven't got back to me
Sorry to reopen this. I habe just found that my D3 sunroof has been attacked by crows.
Did you get to the answer ? are D3 and D4 the same?
Is there any other alternative replacing the glass?
Steve
12th Aug 2024 3:03 pm
HairyFool
Member Since: 04 Jan 2023
Location: North Essex
Posts: 692
The JLR parts site shows the same part no for both the D3 and D4
More importantly the part description has "includes seal" so not replaceable on its own.A visitor from the dark side, my other vehicle is an is still an EV. Strictly speaking its SWMBO.
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum
