Member Since: 14 Nov 2019
Location: Usk
Posts: 401
Most difficult pipe to replace?
I think I have found the most difficult pipe to replace on a D3. Not leaking yet but too risky to ignore. Anyone hazard a guess before I post a photo?Chris
16th Jul 2021 5:03 pm
Pete K
Member Since: 15 Jan 2016
Location: GL
Posts: 10363
Rear brake pipe
16th Jul 2021 5:08 pm
Doughboy
Member Since: 04 Aug 2020
Location: Tamworth
Posts: 90
If you class a brake line being attached to the rear upper control arm which also needs doing as part of the job.. Definitely that lol
16th Jul 2021 5:40 pm
motorworks
Member Since: 14 Nov 2019
Location: Usk
Posts: 401
Several times I have replaced all D3 rear brake pipes, body on, and body off. Can be tricky but there is a technique which makes it straightforward, with a neat finish.
I already have the body off this car. There are two routes to access the pipe, but either way it is going to take a couple of hours to replace.
If the pipe failed, I would expect a £5k car reduced to around £500 scrap value.Chris
And I was going to say "colon" based on just the title..
Dean
====================================
2011 D4 XS - OBD port protection, RLD spare wheel protector, All LED interiors lights, Timed Climate enabled, iiD tool paired.
2011 D4 Landmark - Stolen from same dealer before I paid for it
2011 D4 GS - Stolen whilst at dealer ... All LED interiors lights, DRLs, Spare Wheel protector.
1996 300Tdi - Eaten by tin worms
16th Jul 2021 6:38 pm
lynalldiscovery
Member Since: 22 Dec 2009
Location: Maidstone
Posts: 7274
I would hazard a guess on one of the buried coolant hoses?
16th Jul 2021 8:02 pm
jenseneverest
Member Since: 12 Jun 2017
Location: somewhere
Posts: 764
Hardware wrote:
And I was going to say "colon" based on just the title.
16th Jul 2021 8:28 pm
Disco_Mikey
Member Since: 29 May 2007
Location: Dundee, Scotland
Posts: 20729
Member Since: 14 Nov 2019
Location: Usk
Posts: 401
Here is the problem, main coolant pipe from thermostat to engine block,
Along with three other used pipes "in stock"
This one looked fine from above, but not good underneath,
Do you think this rust is a consequence of vehicle use or quality control?Chris
17th Jul 2021 9:41 pm
kajtzu
Member Since: 11 Aug 2017
Location: Helsinki
Posts: 6570
Ancient Viking burial mounds contain iron ware and weapons that are less rusty than that pipe
What have they done with it? Soaked in the North Sea?
18th Jul 2021 4:48 pm
disco chris
Member Since: 25 Apr 2022
Location: London
Posts: 245
I seem to recall someone on here had an engine failure after this pipe burst and blew all the coolant out onto the road in a matter of seconds... also an article a few years ago in LRO technical bit where someone spotted their pipe was close to failure and already leaking coolant through a pin hole...
Do you think it's necessary to replace as preventative maintenance? Possible to do at home, or how much labour at a garage?
And is it common for this to cause engine failure as the cars get older?
23rd Oct 2023 10:13 pm
PROFSR G
Member Since: 06 Mar 2017
Location: Lost
Posts: 4651
Re: Most difficult pipe to replace?
motorworks wrote:
I think I have found the most difficult pipe to replace on a D3. Not leaking yet but too risky to ignore. Anyone hazard a guess before I post a photo?
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum
... All LED interiors lights, DRLs, Spare Wheel protector.
