Member Since: 31 May 2013
Location: Birmingham
Posts: 226
D4 Coolant Loss
Hi All,
Driving on the motorways today, I certainly received a warning for low coolant. Initially, it felt like a strange occurrence as I recently checked the level and it was fine.
Anyway, when I got home, this is what I saw...
It seems that the engine cover has rubbed its way through the top hose!
Where best to get a replacement? I will have to do a DIY swap tomorrow if I could.
Thanks.D4 HSE all the way
12th Jun 2014 6:59 pm
Mambosasa
Member Since: 31 May 2013
Location: Birmingham
Posts: 226
I just to spoke to parts and this hose is 136 pounds! Really? For a short coolant hose? I find that amazing.
Anyone on here could assist? I am pretty much grounded until I get the hose replaced. D4 HSE all the way
I had to get this hose replaced a few weeks ago for the same reason although i caught it just before it rubbed right through. LR will sell you a complete hose set with thermostat housing for £100+. My indi got the hose on its own for £25 but im not sure where.
13th Jun 2014 9:14 am
Mambosasa
Member Since: 31 May 2013
Location: Birmingham
Posts: 226
A quick update.
I had to sort out a temp measure. Using a hose extension piece, I had to cut the hose and clamp it both sides. It should hold for now until I get it replaced during the week.
I am not prepared to pay that amount of money for a small coolant hose. Its just not necessary.D4 HSE all the way
13th Jun 2014 10:05 am
Mambosasa
Member Since: 31 May 2013
Location: Birmingham
Posts: 226
Oh,
I cleaned the MAP sensor too whilst under there D4 HSE all the way
13th Jun 2014 10:07 am
spb
Member Since: 07 May 2010
Location: Cumbria
Posts: 201
Strongly advise all check this
Just out of curiosity I went out to check mine today and it was showing signs of chafing.
I have wrapped mine with some self amalgamating tape to protect it which will be fine for now, I will monitor it and speak to LR as appropriate.TD4 Freelader ES
TD5 Defender 90 Tombraider LE
TD4 Freelander Kalahari
Another TD5 Defender 90 Tombraider LE
TDV6 Discovery 3 SE
TDV6 Discovery 4 XS
TDV8 L405 Range Rover vogue SE
13th Jun 2014 3:13 pm
betty02
Member Since: 09 Jun 2014
Location: Wakefield
Posts: 133
Hows about trying a company like Samco, and SFS who make hoses? See if it's any cheaper? Other then that you could try eBay, I would be sticking a metal jubilee clip around the area it rubbed too so it's rubbing on metal and not a weak hose!
13th Jun 2014 3:29 pm
Mambosasa
Member Since: 31 May 2013
Location: Birmingham
Posts: 226
Indeed. This is only a temp solution until I get another hose. Its holding fine for now, so I am back on the road.
I have seen several hoses on ebay for a D1, but looks very similar in shape and size, all for a price of a pint.
I wonder whether or not they are interchangeable.
With regards to rubbing, mine seem to have some sort of a sleeve. I wonder whether that is supposed to be there to protect it? I think mine only went yesterday due to the high ambient temps and the fact that I was cruising hard down the motorway.D4 HSE all the way
13th Jun 2014 3:44 pm
adam
Member Since: 20 Sep 2005
Location: Home and Happy
Posts: 6917
Just checked mine - similar chaffing
Called local indy in Stockport - £25, fitting extra - getting it done next week
Yeat another usefull post
13th Jun 2014 4:26 pm
Russell
Member Since: 24 Aug 2007
Location: Kent
Posts: 10564
How old are your D4's is it not covered under warranty, if not I would be on the phone to LRCS asking them about this or even PM Pete and get him on the case.MY17 D5 1st Edition Namib Orange
MY15 D4 HSE Kaikoura Stone
MY12 D4 HSE Nara Bronze Sold and gone
MY11 D4 HSE Stornaway Grey Sold and gone
D3 S spec Silver Sold and gone
Tow bar, full length roof bars, side steps, tow bar storage unit, surround camers.
D4 camera club
13th Jun 2014 5:20 pm
Mambosasa
Member Since: 31 May 2013
Location: Birmingham
Posts: 226
A friend of mine works at JL. He is going to investigate the background to this issue. I will keep you posted.D4 HSE all the way
13th Jun 2014 10:45 pm
adam
Member Since: 20 Sep 2005
Location: Home and Happy
Posts: 6917
Mine is over 4 years old and 70k - I've just Dremmeld the slot so it can't chaff
14th Jun 2014 4:49 pm
SHARKYSHARKS
Member Since: 20 Dec 2008
Location: Saddleworth Oldham
Posts: 1954
Just checked mine and it is starting to chaff MY18 D5 HSE LUX😎
MY12 Freelander SD4 HSE
44 Tonne 12 Litre 6x2 Scania T cab (Current)
Freelander 1 (Wrote off 😫)
Ex D1
Ex D2 GS
Ex V8 D2 GS
Ex D3 S
Ex D4 GS
Club skip ya lockers !!!
Club BAS remote heater !!
Club Duratrac
Club Phillips DRL
Club Prospeed Rack Mk 1
Club Prospeed Rack Mk 2
Club Sankey
Club RLD spare wheel protector
14th Jun 2014 5:11 pm
Mambosasa
Member Since: 31 May 2013
Location: Birmingham
Posts: 226
So, as I said, my friend is investigating this further back at JL. Can you all please confirm the year of your vehicle and if you have any photos of the hose position, please post.
His view is that the engine cover may have been placed incorrectly at some point, but he needs further information.
Thanks.D4 HSE all the way
19th Jun 2014 11:17 am
spb
Member Since: 07 May 2010
Location: Cumbria
Posts: 201
Mine is a 2010.
Can't get you a photo ATM but the first thing I did was remove and refit the engine cover.TD4 Freelader ES
TD5 Defender 90 Tombraider LE
TD4 Freelander Kalahari
Another TD5 Defender 90 Tombraider LE
TDV6 Discovery 3 SE
TDV6 Discovery 4 XS
TDV8 L405 Range Rover vogue SE
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum
I find that amazing.
