Vo Rogue
Member Since: 16 Jan 2006
Location: Melbourne
Posts: 123
![](templates/vbnew/images/spacer.gif)
![2006 Discovery 3 TDV6 SE Auto Arctic Frost 2006 Discovery 3 TDV6 SE Auto Arctic Frost](../images/veh/arctic_frost.gif)
|
To Chip or not to chip - EGT information |
|
Here is a link which really is set up to sell you EGT measurement however it deals with EGT in some detail and what happens to Turbo Diesel motors if normal parameters are exceeded. As it is pointed out in the article excessive EGT can be quite destructive and it would be nice for any of the people chipping Disco 3's to advise how what they are doing is affecting EGT and whether or not (hopefully not) the figures are starting to get close to the limits.
I have to note that at the moment I am hopeing to get my nice new D3 chipped so at the moment am assuming that this stuff has been well taken care of.
http://www.bankspower.com/Tech_whyegt.cfm
|
28th Jan 2006 8:20 am |
|
|
Slimer
Site Moderator
Member Since: 06 Jan 2005
Location: Last Exit to Nowhere
Posts: 16295
![](templates/vbnew/images/spacer.gif)
|
Interesting reading, I know Dastek always speak of the importance of EGTs, now I know why The End
|
28th Jan 2006 10:37 am |
|
|
JE Engineering
Member Since: 23 Jan 2006
Location: Coventry
Posts: 19
![](templates/vbnew/images/spacer.gif)
|
We had thermocouples in the turbos of both our manual and auto test cars from day one, EGT was a major factor in deciding how far we could push the JE tune.
|
28th Jan 2006 11:32 am |
|
|
LRtuning
Member Since: 22 Feb 2005
Location: AUSTRALIA + UK
Posts: 468
![](templates/vbnew/images/spacer.gif)
![2006 Discovery 3 TDV6 SE Auto Adriatic Blue 2006 Discovery 3 TDV6 SE Auto Adriatic Blue](../images/veh/adriatic_blue.gif)
|
We are fully aware of EGT temperature issues given our experience with Heavy Commercial Vehicles and the constant load and 'punishment' they take on a day-to-day basis.
The 'Banks' article was interesting and highlighted in particular the need to keep the air/fuel ration in proportion to avoid excessive increases in the EGT. Here at TC (as I'm sure JE also have done) we balance the increases in fuelling with additional turbo pressure to maintain the EGT within the normal heat range. We also alter 'throttle demand' and engine load demand so that you only get the extra torque when you need it
EGT is certainly one area where the 'plug in' tuning type boxes are lacking. Many of these boxes only increase fuel pressure without any regard to EGT whereas a 're-map' or reprogramming of a vehicles' ecu by an experienced tuner can address this issue with total confidence. Money talks.Sex sells.Mud sticks.Time flys. happens.People talk.Impressions last!
Last edited by LRtuning on 29th Jan 2006 8:46 am. Edited 1 time in total
|
28th Jan 2006 5:57 pm |
|
|
dazzpowder
Member Since: 27 Jan 2006
Location: London
Posts: 47
![](templates/vbnew/images/spacer.gif)
![2005 Discovery 3 TDV6 HSE Auto Zambezi Silver 2005 Discovery 3 TDV6 HSE Auto Zambezi Silver](../images/veh/zambezi_silver.gif)
|
Does your company do an ecu mod?
|
29th Jan 2006 2:29 am |
|
|
LRtuning
Member Since: 22 Feb 2005
Location: AUSTRALIA + UK
Posts: 468
![](templates/vbnew/images/spacer.gif)
![2006 Discovery 3 TDV6 SE Auto Adriatic Blue 2006 Discovery 3 TDV6 SE Auto Adriatic Blue](../images/veh/adriatic_blue.gif)
|
Dazz
Yes, we offer an ecu upgrade via the car's OBD diagnostic socket
PM me your mobile and I'll answer any questions you have Money talks.Sex sells.Mud sticks.Time flys. happens.People talk.Impressions last!
|
29th Jan 2006 8:34 am |
|
|
scorpio
Member Since: 26 Feb 2005
Location: Birmingham
Posts: 237
![](templates/vbnew/images/spacer.gif)
![2006 Discovery 3 TDV6 S Auto Arctic Frost 2006 Discovery 3 TDV6 S Auto Arctic Frost](../images/veh/arctic_frost.gif)
|
turbochip
I have 3 questions
1. you say it cannot be found by LR at all, do you give a written guarantee to that effect.
2. Will my auto gearbox be able to cope with the power hike, and do you offer a guarantee to that effect as well if it can.
3. Does it affect my LR warranty in anway shape or form, and if I was to have a problem can I come back to you if LR refuse to warranty the vehicle.
Sorry about this but I want it done but I really need to be 100% sure first.
Peter
|
29th Jan 2006 12:23 pm |
|
|
Vo Rogue
Member Since: 16 Jan 2006
Location: Melbourne
Posts: 123
![](templates/vbnew/images/spacer.gif)
![2006 Discovery 3 TDV6 SE Auto Arctic Frost 2006 Discovery 3 TDV6 SE Auto Arctic Frost](../images/veh/arctic_frost.gif)
|
scorpio wrote:turbochip
2. Will my auto gearbox be able to cope with the power hike, and do you offer a guarantee to that effect as well if it can.
Peter
Hi there Peter. I am not TC and haveing started this thread you can be sure that I am interested in general in the replies.
As far as the Auto Box is concerned, I run an older BMW V12 with 450 NM of Torque (65,000 miles since new). That runs a ZF HP24 Box and the reason that BMW could not run those engines and the later ones at higher powers was that they did not have a box that could take the torque - "blew them to bits" - was the description. The ZF24 box by the way was also used in some RRovers and was quite a robust unit. The later 6.0litre V12's are running ZF 6HP26 Box's which according to the early figures were rated for 600 NM so that would not appear to be an issue - no guarantees from me by the way but I will take the chance
|
29th Jan 2006 12:47 pm |
|
|
LRtuning
Member Since: 22 Feb 2005
Location: AUSTRALIA + UK
Posts: 468
![](templates/vbnew/images/spacer.gif)
![2006 Discovery 3 TDV6 SE Auto Adriatic Blue 2006 Discovery 3 TDV6 SE Auto Adriatic Blue](../images/veh/adriatic_blue.gif)
|
Peter
I can assure you that LR diagnostics cannot find our Turbochip product. I deal exclusively with the biggest LR dealer in Europe and I can confirm this verbally or by letter if required. I have upgraded in excess of 50 TDV6's (All brand new vehicles) for them and they would be happy to deal with you giving the assurances you may require @ £1250 + vat
Your auto box can cope with the extra torque as it designed to for both the forthcoming TDV6 3.0 and the TDV8 3.6 without specification change. We do not provide any additional warranty on your gearbox as you can still rely on your LR warranty.
We do not offer any additional warranty and we have now modified in excess of 270 TDV6 engines over the last 14 months without any issue whatsoever and there are no incidences of LR 'discovering' the upgrade.
Be wary of any company offering a 'warranty' or 'insurance' to that effect.
I tried to negotiate such a deal with Firebond PLC who provide Superchips with a 'claims handling' service and they confirmed to me that Schips does not have an 'under written' insurance policy as their literature might suggest. It is effect an arbitration service that would try to negotiate with the manufacturer/ customer should a problem arise and ultimately Schips would 'write a cheque' if the manufacturer 'walked away' from the warranty.
It doesnt however mention the timescales involved nor what happends in the meantime whilst schip and the manufacturer 'argue' over who's to blame for any possible failures etc.
" If you have a big nose why underline it with a moustache!" Money talks.Sex sells.Mud sticks.Time flys. happens.People talk.Impressions last!
|
29th Jan 2006 12:54 pm |
|
|
prawn
Member Since: 06 Jan 2006
Location: West Sussex
Posts: 28
![](templates/vbnew/images/spacer.gif)
![2006 Discovery 3 TDV6 HSE Auto Zambezi Silver 2006 Discovery 3 TDV6 HSE Auto Zambezi Silver](../images/veh/zambezi_silver.gif)
|
Sorry to go off topic.
Chris did you get my mobile number ? Zambezi Silver TDV6 HSE - TC'd
Discovery 300tdi - 119K and still going strong
Radical Clubsport 1100 - for a bit of fun
|
30th Jan 2006 11:37 am |
|
|
LRtuning
Member Since: 22 Feb 2005
Location: AUSTRALIA + UK
Posts: 468
![](templates/vbnew/images/spacer.gif)
![2006 Discovery 3 TDV6 SE Auto Adriatic Blue 2006 Discovery 3 TDV6 SE Auto Adriatic Blue](../images/veh/adriatic_blue.gif)
|
Sure did Money talks.Sex sells.Mud sticks.Time flys. happens.People talk.Impressions last!
|
30th Jan 2006 12:17 pm |
|
|
jacob
Member Since: 12 Jan 2006
Location: athens
Posts: 145
![](templates/vbnew/images/spacer.gif)
![2006 Discovery 3 TDV6 SE Auto Vienna Green 2006 Discovery 3 TDV6 SE Auto Vienna Green](../images/veh/vienna_green.gif)
|
hi toubochip and j.e, do you hv both of u any authorised dealer in greece which can upgrade my D3. ???
|
30th Jan 2006 1:44 pm |
|
|
LRtuning
Member Since: 22 Feb 2005
Location: AUSTRALIA + UK
Posts: 468
![](templates/vbnew/images/spacer.gif)
![2006 Discovery 3 TDV6 SE Auto Adriatic Blue 2006 Discovery 3 TDV6 SE Auto Adriatic Blue](../images/veh/adriatic_blue.gif)
|
Are you near Athens? Money talks.Sex sells.Mud sticks.Time flys. happens.People talk.Impressions last!
|
30th Jan 2006 2:07 pm |
|
|
jacob
Member Since: 12 Jan 2006
Location: athens
Posts: 145
![](templates/vbnew/images/spacer.gif)
![2006 Discovery 3 TDV6 SE Auto Vienna Green 2006 Discovery 3 TDV6 SE Auto Vienna Green](../images/veh/vienna_green.gif)
|
yes, very close to old airport(elliniko) abt 10 kms frm center of athens.
|
30th Jan 2006 2:12 pm |
|
|
LRtuning
Member Since: 22 Feb 2005
Location: AUSTRALIA + UK
Posts: 468
![](templates/vbnew/images/spacer.gif)
![2006 Discovery 3 TDV6 SE Auto Adriatic Blue 2006 Discovery 3 TDV6 SE Auto Adriatic Blue](../images/veh/adriatic_blue.gif)
|
When is good for you? Money talks.Sex sells.Mud sticks.Time flys. happens.People talk.Impressions last!
|
30th Jan 2006 4:21 pm |
|
|