Advertise on DISCO3.CO.UK
Forum · Gallery · Wiki · Shop · Sponsors
DISCO3.CO.UK > Faults & Fixes (D3)

cold heater
Post Reply  Down to end
Page 1 of 2 12>
toby653
 


Member Since: 16 Dec 2011
Location: ypres
Posts: 26

Belgium 2005 Discovery 3 TDV6 S Auto Java BlackDiscovery 3
cold heater

hi

The heater on my discovery 3 will only blow very cold and has no heat the temperature guage is just above the blue mark and never goes any higher any ideas would this be caused by an air lock in the cooling system it has just happened the coolant level hasnt dropped how can i cure an air lock if that is the cause many thanks
  
Post #87197516th Dec 2011 10:26 pm
View user's profile Send private message View poster's gallery Reply with quote
MrH
 


Member Since: 08 Aug 2007
Location: lost in the forest
Posts: 7754

United Kingdom 

Unless you recently had the coolant changed I say it's unlikely to be an air lock, more like a thermostat issue.
  
Post #87198516th Dec 2011 11:09 pm
View user's profile Send private message View poster's gallery Reply with quote
anglefire
 


Member Since: 09 Mar 2010
Location: In the Club House
Posts: 4180

England 

Does sound like a thermostat issue - though when I changed my radiator Nick did say that he didn;t recall any being replaced as they were reliable.

It is quite a complicated system as well - opens on temperature and pressure - might be worth seeing if the cap is ok - though that would not really make sense as they tend to cause boiling if its not holding the pressure.
 Mark.
2006, D3 SE Auto - gone but not forgotten.
2014 BMW 530d M Sport Tourer.
1977 Triumph Spitfire 1500

_________________________________________________
Disco Picture Website Here 
 
Post #87203317th Dec 2011 10:52 am
View user's profile Send private message View poster's gallery Reply with quote
Spooky
 


Member Since: 02 Jun 2009
Location: Swindon, Wilts
Posts: 1013

United Kingdom 

Is your FBH cutting in? In these cold conditions, the engine is very reluctant to get up to temperature ...
 Regards,
Mick

- 2014 SDV8 Autobiography
- 'Vincent' - 2010 TdV8 Vogue SE
- 'Molly' - 2005 HSE Auto
'Dixie'
- 2000 D2 Td5 ES
 
 
Post #87207017th Dec 2011 1:24 pm
View user's profile Send private message View poster's gallery Reply with quote
anglefire
 


Member Since: 09 Mar 2010
Location: In the Club House
Posts: 4180

England 

My FHB is knackered and the engine still gets to temperature in about 5-8miles down to about 2'C

And the stat is arranged to get heat to the heater matrix first I believe.

Could be the stat is stuck open - my old defender would get to temperature if on a motorway run - but would cool again very quickly when coming off - but found the stat was missing completely Big Cry But that can't happen on the D3 as far as I can tell due to it having about 4 pipes from it.
 Mark.
2006, D3 SE Auto - gone but not forgotten.
2014 BMW 530d M Sport Tourer.
1977 Triumph Spitfire 1500

_________________________________________________
Disco Picture Website Here 
 
Post #87207317th Dec 2011 1:46 pm
View user's profile Send private message View poster's gallery Reply with quote
toby653
 


Member Since: 16 Dec 2011
Location: ypres
Posts: 26

Belgium 2005 Discovery 3 TDV6 S Auto Java BlackDiscovery 3

thank you for all your replies i am none the wiser the vehicle hasnt had any work done on the coolant system i just cant understand it it was fine and now the heaters are freezing cold and the engine temp guage will only just register above the blue segment of the guage. I have been out today looking at it and havent come to any conclusions except that when the lid is taken off the expansion tank the water bubbles up the vehicle has never over heated and appears perfectly normal to drive and operate apart from being cold i have been out in it this afternoon and the heater did start to blow slightly warmer air through after a 12 mile trip but engine still only on the blue.
  
Post #87216317th Dec 2011 6:22 pm
View user's profile Send private message View poster's gallery Reply with quote
sowr
 


Member Since: 07 Feb 2009
Location: Los Angeles, CA
Posts: 46

United States 2006 LR3 4.4 V8 SE Auto Zermatt SilverLR3

Hmmm - does the engine feel warm or hot? If you let the car sit for a while (15 minutes or so) does the coolant level in the expansion tank drop dramatically? Can you hear cavitation (clicking/popping/snapping)? Perhaps there's no coolant in your system?

Or maybe it's logic based? My wife's Volvo would sometimes blast out freezing cold air even when I had set the temp to warm - restart and it would fix itself.
 2006 LR3 SE-7 Zermatt Silver
Technology Package 
 
Post #87227018th Dec 2011 3:52 am
View user's profile Send private message View poster's gallery Reply with quote
toby653
 


Member Since: 16 Dec 2011
Location: ypres
Posts: 26

Belgium 2005 Discovery 3 TDV6 S Auto Java BlackDiscovery 3

the engine feels warm or hot after a journey depending on how long its been running for. i still think is has an air lock the coolant level doesnt drop after being run.

what does the black screw/plug do beside the expansion tank filler cap towards the front of the car? how can i blled the cooling system of air as? im not sure what is the correct sequence of doing things as the system needs the filler cap on for the stat to open etc. Can i start the vehicle and loosen the screw (as mentioned above) and then keep topping up with coolant or leave filler cap off?

Hoping to get to the bottom of this as working nights with the vehicle isnt much fun with a cold heater.
  
Post #87246018th Dec 2011 7:46 pm
View user's profile Send private message View poster's gallery Reply with quote
disco_steve
 


Member Since: 25 Aug 2009
Location: Are you sure this is the M5 ?
Posts: 1498

England 2006 Discovery 3 TDV6 HSE Auto Arctic FrostDiscovery 3

Hi Toby,

Have a look at this, you will need section 19 onward for bleeding (you may not have rear heating/aircon) so ignore the reference to this as required.

http://www.disco3.co.uk/gallery/albums/use...eeding.pdf

I found that running the engine whilst filling/bleeding helped remove any stubborn trapped air in the system Thumbs Up
 Never get mad - get even !!

06 D3 now gone to family member and still going strong at 265k

previous vehicles:
04 D2 TD5 - (clocked 189k from new)
52 X-Trail 2.2 SVE
various euro boxes ! 
 
Post #87250518th Dec 2011 8:38 pm
View user's profile Send private message View poster's gallery Send e-mail Reply with quote
Narpy
 


Member Since: 18 Jul 2011
Location: Stockport
Posts: 7830

2005 Discovery 3 TDV6 S Manual Cairns BlueDiscovery 3

If you were driving an old 4 cylinder Discovery 1 Toby, I'd have no problems in diagnosing a defective head gasket from the symptoms you describe. Heater blowing cold, not getting warm and coolant bubbling up are all classic pointers to a failed head gasket.
Pull the dipstick and see if there are water droplets visible or check if your oil has turned to mayonnaise. These were/are "full on" symptoms on the D1 and you may have all or none of these but a compression test should be high up your list of priorities. Wink

Sorry I can't help further but the TDV6 engine is still relatively new to me so exact HG failure symptoms will obviously need clarification. Rolling Eyes
  
Post #87258718th Dec 2011 11:57 pm
View user's profile Send private message View poster's gallery Reply with quote
toby653
 


Member Since: 16 Dec 2011
Location: ypres
Posts: 26

Belgium 2005 Discovery 3 TDV6 S Auto Java BlackDiscovery 3

firstly thank you to disco_steve your link for blleding the coolant system was very helpful

there is no sign of water on the dipstick and as ive said before vehicle has never over heated im the only one who drives it

what is the best way to drain the colling system fully, is it bottom hose off the radiator or what?
  
Post #87305319th Dec 2011 8:31 pm
View user's profile Send private message View poster's gallery Reply with quote
disco_steve
 


Member Since: 25 Aug 2009
Location: Are you sure this is the M5 ?
Posts: 1498

England 2006 Discovery 3 TDV6 HSE Auto Arctic FrostDiscovery 3

Yep - bottom rad hose - undue jubilee clip, but . . .

If you have rear heating/aircon (HSE models with rear climate) then you also need to remove spare wheel, and disconnect one of the hoses to drain the rear end of the car as well Thumbs Up
 Never get mad - get even !!

06 D3 now gone to family member and still going strong at 265k

previous vehicles:
04 D2 TD5 - (clocked 189k from new)
52 X-Trail 2.2 SVE
various euro boxes ! 
 
Post #87310919th Dec 2011 9:59 pm
View user's profile Send private message View poster's gallery Send e-mail Reply with quote
toby653
 


Member Since: 16 Dec 2011
Location: ypres
Posts: 26

Belgium 2005 Discovery 3 TDV6 S Auto Java BlackDiscovery 3

right i had some free time so set to about draining the coolant out firstly not much came out or not as much as i expected filled it all back up as suggested on disco_steves link and the cylinder head bleed screw will emitt water but the expansion tank bleed screw will just froth up so closed it and left engine to run the temp needle got up to exactly half way and stayed there but still cold on the heaters water level in expansion tank at constant normal level. turned vehicle off and level in expansion tank rose up to near an inch from the lid. tried to loosen bleed screws when the engine was off the cylinder head bleed screw was misture or air and water in spirts and expansion tank one was just bubbly water etc so no further forward and then I had to go off to work and vehicle would only run at just off the blue on the temp guage Got to keep driving the vehicle at the moment to work as im on call all this week (Im a fireman out here in Belgium) and would like to go over and see family at Christmas which is a big run!

Is it time for a new vehicle as its probably cylinder head or gasket? or is it something else? Not a vast knowledge out here in Belgium of these vehicles and is the cylinder head worth doing on a vehicle thats done just over 300,000 mile
  
Post #87355420th Dec 2011 9:22 pm
View user's profile Send private message View poster's gallery Reply with quote
toby653
 


Member Since: 16 Dec 2011
Location: ypres
Posts: 26

Belgium 2005 Discovery 3 TDV6 S Auto Java BlackDiscovery 3

Hello been over 700 miles in the last two days and still exactly the same with cold heaters except im using water had to put in half a litre. heater still cold but temperature guage will get up to just under the horizontal normal position when on the motorway but as soon as the revs are dropped then it soon drops down towards the blue apart from that it runs fine which seems odd if the head gasket has gone or its something major as I would have though it would be doing something exciting by now such as water in the oil etc.
  
Post #87490623rd Dec 2011 7:28 pm
View user's profile Send private message View poster's gallery Reply with quote
countrywide
 


Member Since: 16 Sep 2007
Location: UK
Posts: 6019

United Kingdom 2016 Discovery 4 3.0 SDV6 Graphite LE Auto Unknown ColourDiscovery 4

Still sounds like thermostat to me. Had this on my Defender recently too, new thermostat fixed it.

I would try that first.
  
Post #87491423rd Dec 2011 7:47 pm
View user's profile Send private message View poster's gallery Reply with quote
Display posts from the last:  
Post Reply Back to top
Page 1 of 2 12>
Jump to:  
Previous Topic | Next Topic >


Posting Rules
You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum



DISCO3.CO.UK Copyright © 2004-2024 Futuranet Ltd & Martin Lewis
DISCO3.CO.UK RSS Feed - All Forums

DISCO3.CO.UK is independent and not affiliated to Land Rover.
Switch to Mobile Site